JOURNAL BROWSE
Search
Advanced SearchSearch Tips
Analysis of Operation Parameters of Pilot-Scale Packed-Absorption System for Airborne Methyl Ethyl Ketone Control
facebook(new window)  Pirnt(new window) E-mail(new window) Excel Download
 Title & Authors
Analysis of Operation Parameters of Pilot-Scale Packed-Absorption System for Airborne Methyl Ethyl Ketone Control
Jo, Wan-Kuen; Kim, Wang-Tae;
  PDF(new window)
 Abstract
Unlike many laboratory-scale studies on absorption of organic compounds (VOCs), limited pilot-scale studies have been reported. Accordingly, the present study was carried out to examine operation parameters for the effective control of a hydrophilic VOC (methyl ethyl ketone, MEK) by applying a circular pilot-scale packed-absorption system (inside diameter 37 cm height 167 cm). The absorption efficiencies of MEK were investigated for three major operation parameters: input concentration, water flow rate, and ratio of gas flow-rate to washing water amount (water-to-gas ratio). The experimental set-up comprised of the flow control system, generation system, recirculation system, packed-absorption system, and outlet system. For three MEK input concentrations (300, 350, and 750 ppm), absorption efficiencies approached near 95% and then, decreased gradually as the operation time increased, thereby suggesting a non-steady state condition. Under these conditions, higher absorption efficiencies were shown for lower input concentration conditions, which were consistent with those of laboratory-scale studies. However, a steady state condition occurred for two input concentration conditions (100 and 200 ppm), and the difference in absorption efficiencies between these two conditions were insignificant. As supported by an established gas-liquid absorption theory, a higher water flow rate exhibited a greater absorption efficiency. Moreover, as same with the laboratory-scale studies, the absorption efficiencies increased as water-to-gas ratios increased. Meanwhile, regardless of water flow rates or water-to-gas ratios, as the operation time of the absorption became longer, the pH of water increased, but the elevation extent was not substantial (maximum pH difference, 1.1).
 Keywords
Pilot-scale;Input concentration;Water-to-gas ratio;Water flow rate;Absorption efficiency;pH;
 Language
Korean
 Cited by
 References
1.
Arzamendi, G., de la Pena O'Shea, V. A., Alvarez-Galvan, M. C., Fierro, J. L. G., Arias, P. L., Gandia, L. M., 2009, Kinetics and selectivity of methyl-ethyl-ketone combustion in air over alumina-supported $PdO_x-MnO_x$ catalysts, J. Catal., 261, 50-59. crossref(new window)

2.
Boltes, K., Caro, A., Leton, P., Rodriguez, A., Garcia-Calvo, E., 2008, Gas-liquid mass transfer in oil-water emulsions with an airlift bio-reactor, Chem. Eng. Proc., 47, 2408-2412. crossref(new window)

3.
Daubert-Deleris, I., Hoffmann, P. A., Fonade, C., Maranges, C., 2006, Hydrodynamic and mass transfer performance of a new aero-ejector with its application to VOC abatement, Chem. Eng. Sci., 61, 4982-4993. crossref(new window)

4.
Devinny, J. S., Deshusses, M. A., Webster, T. S., 2001, Biofiltration for Air Pollution Control, Lewis Publishers, Boca Raton, 3-8.

5.
Dosta, J., Rovira, J., Gali, A., Mace, S., Mata-Alvarez, J., 2008, Integration of a Coagulation/Flocculation step in a biological sequencing batch reactor for COD and nitrogen removal of supernatant of anaerobically digested piggery wastewater, Biores. Technol., 99, 5722-5730. crossref(new window)

6.
Dubray, A., Vanderschuren, K., 2004, Mass transfer phenomena during sorption of hydrophilic volatile organic compounds into aqueous suspensions of activated carbon, Sep. Puri. Technol., 38, 215-223. crossref(new window)

7.
El Hajjouji, H., Bailly, J. R., Winterton, P., Merlina, G., Revel, J. C., Hafidi, M., 2008, Chemical and spectroscopic analysis of olive mill waste water during a biological treatment, Biores. Technol., 99, 4958-4965. crossref(new window)

8.
Glowa, G., Driver, P., Wren, J. C., 2000, Irradiation of MEK D II: A detailed kinetic model for the degradation of 2-butanone in aerated aqueous solutions under steady-state g-radiolysis conditions, Rad. Phys. Chem., 58, 49-68. crossref(new window)

9.
Heymes, F., Demoustier, P. M., Charbit, F., Fanlo, J. L., Moulin, P., 2007, Treatment of gas hydrophobic VOCs by a hybrid absorption-pervaporation process: The case of toluene, Chem. Eng. Sci., 62, 2576-258. crossref(new window)

10.
Hudson, R., Arriola, A., Martínez-Gomez, M., Distel, H., 2006, Effect of air pollution on olfactory function in residents of Mexico city, Chem. Senses, 31, 79-85.

11.
Merchuk, J. C., Rosenblat, Y., Berzin, I., 2007, Fluid flowand mass transfer in a counter-current gas–.liquid inclined tubes photo-bioreactor, Chem. Eng. Sci., 62, 7414-7425. crossref(new window)

12.
Navarro-Laboulais, J., Cardona, S. C., Torregrosa, J. J., Abad, A., Lopez, F., 2008, Practical identifiability analysis in dynamic gas-liquid reactors optimal experimental design for mass-transfer parameters determination, Comp. Chem. Eng., 32, 2382-2394. crossref(new window)

13.
Ozturk, B., Yilmaz, D., 2006, Absorptive removal of volatile organic compounds from flue gas streams, Proc. Safety Environ. Protect., 84, 391-398. crossref(new window)

14.
Pandey, S. K., Kim, K. H., 2009, Simulteneous determination of odorous volatile organic compounds with gas chromatography and a thermal desorber: A case study on methyl ethyl ketone, methyl isobutyl ketone, butyl acetate, and xylene, Microchem. J., 91, 245-252. crossref(new window)

15.
Patrick, D. R., 1994, Toxic Air Pollution Handbook, Van Nostrand Reinhold, NY, 390-397.

16.
Raghuvanshi, S., Babu, B. V., 2009, Experimental studies and kinetic modeling for removal of methyl ethyl ketone using biofiltration, Biores. Technol., 100, 3855-3861. crossref(new window)

17.
USEPA (United States of Environmental Protection Agency), 2003, Toxicological review of methyl ethyl ketone (CAS No. 78-93-3), In Support of Summary Information on the Integrated Risk Information System (IRIS), 1-99.

18.
Verschueren, K., 1996, Handbook of Environmental Data on Organic Chemicals, 3rd ed., Van Nostrand Reinhold, New York, 1292-1294.

19.
Wu, H. H., Lin, S. S., Lai, C. C., 2001, Control of volatile organic compounds (VOC) from semiconductor manufacturing industry by wet scrubbing and ozonation, Proceedings of the Air & Waste Management Association's Annual Conference & Exhibition, Pittsburg, PA, 24-28.

20.
Yin, Y., Zhang, X., Peng, D., Li, X., 2009, Model validation and case study on internally cooled/heated dehumidifier/regenerator of liquid desiccant systems, Int. J. Therm. Sci., 48, 1664-1671. crossref(new window)