Journal of the Korean Ceramic Society (한국세라믹학회지)

The Korean Ceramic Society (한국세라믹학회)
권호 표지

Mechanical Properties of the Ceramics of the System Al2O3-ZrO2-Y2O3 Prepared by the Precipitation Method

침전법에 의한 Al2O3-ZrO2-Y2O3계 세라믹스의 기계적 특성

  • 김준태 (연세대학교 공과대학 요업공학과) ;
  • 이홍림 (연세대학교 공과대학 요업공학과)
  • Published : 1988.04.01
Download PDF
⟨ Previous Next ⟩

Abstract

The mechanical properties and microstructure of ceramics of the system Al2O3-ZrO2-Y2O3 sintered at 1$650^{\circ}C$ for 2h after powder preparation by the precipitation method from Al2(SO4)3.18H2O, ZrOCl2.8H2O and YCl3.6H2O were investigated. The Al2O3-ZrO2-Y2O3 ceramics sintered at 1$650^{\circ}C$ for 2h after mixing alpha-Al2O3 and ZrO2-Y2O3 powders, both were separately precipitated and calcined, were found to have the relative density higher than 97.5% so that the strengthening and toughening mechanisms could be explained mainly as the stress-induced phase transformation. On the other hand, the sintered bodies prepared by co-precipitating the three starting materials were measured to have the relative density lower than 85% so that the degradation of strength were observed above 15 vol% ZrO2 contents due to the high porosity by which the effect of stress-induced phase transformation was assumed to be depressed.

Keywords

References

  1. advanced in Ceramics v.3 Martensite Transformation;Science and Technology of Zirconia C.M. Wayman
  2. advanced in Ceramics Alloy Design in Partially Stabilized Zirconia A.H. Heuer
  3. J. Mater Sci v.13 Effect of Stress Induced Phases Transformation on the Properties of Polycrystalline Zirconia Containing Metastable Tetragonal Phase T.K. Gupta(et al.)
  4. J. Am. Ceram. Soc. v.61 no.1-2 Stress-Induced Transformation of Tetragonal ZrO₂Particles in Ceramic Matrics Nils Claussen
  5. J. Am. Ceram. Soc. v.59 no.1-2 Fracture Toughness of Al₂O₃with an Unstabilized ZrO₂Dispersed Phase Nils Claussen
  6. J. Am. Ceram. Soc. v.56 no.6 Effect of Induced Microcracking on the Fracture Toughness of Ceramics Nils Claussen(et al.)
  7. J. Am. Ceram. Soc. no.12 Critical Microstructure for Microcracking in Al₂O₃-ZrO₂Composites David J. Green
  8. J. Mater Sci. v.17 Transformation Toughening, Part3 Experimental Observations in the ZrO₂-Y₂O₃System F.F. Lange
  9. J. Phy. Chem. v.69 The Occurrence of Metastable Tetragonal Zirconia as a Crystallite Size Effect R.C. Garvie
  10. J. Am. Ceram. Soc. v.45 no.12 Effect of Pressure on Monoclinic-Tetragonal Zirconia as a Crystallite Size Effect E.D. Whitday
  11. J. Am. Ceram. Soc. v.67 no.3 Hindrance of Grain Growth in Al₂O₃by ZrO₂Inclusion F.F. Lange
  12. J. Am. Ceram. Soc. v.56 no.12 Stability of Tetragonal ZrO₂Particles in Ceramic Matrics A.H. Heuer(et al.)
  13. J. Kor. Ceram. Soc. v.25 no.2 Powder Properties of Al₂O₃-ZrO₂-Y₂O₃System Prepared by Precipitation Method J.T. Kim;G.G. Hong;H.L. Lee
  14. J. Am. Ceram. Soc. v.55 no.6 Phase Analysis in Zirconia System R.C. Garvie;P.S. Nicholson
  15. J. Am. Ceram. Soc. v.59 no.7;8 Fracture Toughness Determination by Indentatioin A.G. Evans;E.A. Charles
  16. Effect of Inclusion Size on the Retention of Tetragonal ZrO₂:Theory and Experiments F.F. Lange;D.J. Green
  17. Advanced in Ceramics v.12 Rippening of Inter-and Intragranular ZrO₂Particles in ZrO₂-Toughened Al₂O₃ B.W. Kibbel;A.H. Heuer
  18. J. Am. Ceram. Soc. v.69 no.2 Stability of ZrO₂phases in Ultrafine ZrO₂-Al₂O₃Mixture Yoshio Murage(et al.)
  19. J. Am. Ceram. Soc. v.69 no.3 Exaggerated Grain Growth in ZrO₂-Toughened Al₂O₃ B. Kibbel;A.H. Heuer
  20. Introduction To Ceramics W.D. Kingery;H.K. Bowen;D.R. Uhlmann(ed.)
  21. J. Eng. Research Institute v.18 no.2 Effect of Y₂O₃Contents on Properties of Al₂O₃-ZrO₂Ceramics H.L. Lee;J.T. Kim;G.G. Hong;H.B. Lee