Effect of Ratios Carbon Source to Nitrogen Source on the Yields of PHB Fermentation Variables

탄소원과 질소원의 비가 PHB 발효특성치 수율에 미치는 영향

  • 백예영 (인하대학교 공과대학 생물공학과) ;
  • 허병기 (인하대학교 공과대학 생물공학과)
  • Published : 1994.10.01

Abstract

The effects of ratios of initial concentration of carbon source to the initial concentration of nitrogen source in the fermentation media on both the yields of PHB fermentation variables and the accumulation of poly-${\beta}$-hydroxybutyric acid(PHB) were investigated. The fermentation media were composed of the combination of varing glucose concentrations, 10, 20, 25, 30, 40, $50g/\ell$ and the NH4Cl concentrations 0.33, 0.4, 0.5, 1.5, 3, $5g/\ell$. The yield of biomass on glucos, Yx/s, decreased very slowly according to the increase of the ratio of C to N. And the yield became constant at 0.35(g biomass/g glucose) with the ratio higher than 70. The yield of residual biomass, Yx/s, also decreased with the ratio of C to N and finally showed a constant value of 0.065(g residual biomass/g glucose) when the ratio was higher than 65. In accordance with the augmentation of the ratio, the yield of PHB, YPHB/S, however, increased and showed the maximum value of 0.35 (g PHB/g glucose) between 40 and 60 of the ratio. The maximum yield of PHB to the change of biomass, YPHB/S, was 0.87(g PHB/g biomass), and the yie1d YPHB/RX, was 4.2(g PHB/g residual biomass). The maximum accumulation percent of PHB to the final biomass was 81% when the ratio was higher than 67.

포도당의 초기농도 10, 20, 25, 30, 40, $50g/\ell$$NH_4Cl$의 초기농도 0.33, 0.4, 0.5, 1.5, 3, $50g/\ell$ 의 조 합으로 형성된 발효배지를 사용하여 탄소원과 질소 원의 초기 조성비 C/N이 각종 발효 변수의 수율 및 PHB 축적량에 마치는 영향을 규명하여 보았다. 탄소원의 소비량에 대한 균체 수율 $Y_{X/X}$는 C/N비가 증가함에 따라 대단히 완만하게 감소하였으며 C/N비 70 이상에서는 일정한 값 0.35( g cell biomassl g glucose)를 나타내였다. 잔여균체 수율 $Y_{RX/S}$C/N비가 증가하면 감소하며 C/N비 65 이상에서는 일정한 값 0.065( g residual biomassl g glucose)를 나타내였다. 그러나 PHB의 수율 $Y_{PHB/S}$는 C/N비의 증가에 따라 상승하여 C/N비 40 내지 60 사이에서 최대수율 0.35( g PHB/g glucose)를 나타내었다. 균체증가량에 대한 PHB의 생성수율 $Y_{PHB/S}$는 C/N비의 증가에 따라 증가하나 C/N비 70 이상에셔는 일정한 값 0.83( g PHB/g cell mass)을 유지하였다. 또한 잔여균체량에 대한 PHB의 생성수율도 C/N비 의 증가에 따라 증가하였으며 탄소원이 더이상 소모 되지 않는 상태에셔의 건조균체량에 대한 PHB 축 적률은 C/N비에 따라 상승하여 최대값 81%에 도 달하였다. 이 경우에 대한 C/N값은 67 근방이었으 며 이 이상의 C/N비에 대한 PHB의 축적률은 81% 로 일정하였다.

Keywords