Journal of the Korean Ceramic Society (한국세라믹학회지)

The Korean Ceramic Society (한국세라믹학회)
권호 표지
DOI QR코드

DOI QR Code

Effect of SiO2 on Abnormal Grain Growth and Single Crystal Growth in BaTiO3

BaTiO3에서 SiO2 첨가에 의한 비정상 입성장과 단결정 성장

  • 김재석 (선문대학교 재료화학공학부) ;
  • 허태무 (선문대학교 재료화학공학) ;
  • 이종봉 (선문대학교 재료화학공학) ;
  • 이호용 (선문대학교 재료화학공학부)
  • Published : 2004.03.01
Download PDF
⟨ Previous Next ⟩

Abstract

A very small amount of SiO$_2$ was locally added in sintered BaTiO$_3$ ceramics and then heat-treated at 135$0^{\circ}C$. In the region where SiO$_2$ was not added, grain growth occurred very slowly. In the region where a very small amount of SiO$_2$ was added, however, grain growth occurred very actively. After long time annealing at 135$0^{\circ}C$, abnormal grains appeared only in the part where SiO$_2$ was added and grew up to 2 cm in size. In the grown abnormal grains or single crystals, (111) double or single twins were not observed. The growth of abnormal grains or single crystals was explained by formation of liquid phase in the region where SiO$_2$ was added. These results showed that centimeter-sized BaTiO$_3$ single crystals without (111) double or single twins could be fabricated by using abnormal grain growth.

BaTiO$_3$ 소결체에 국부적으로 SiO$_2$를 첨가하고 열처리하여 비정상 입성장을 유도하였다. 열처리 중에 SiO$_2$가 첨가되지 않은 부분에서는 BaTiO$_3$ 기지상 입자의 성장이 아주 느리게 일어났으나, SiO$_2$가 첨가된 부분에서는 BaTiO$_3$ 기지상 입자가 빠르게 성장하였다. 장시간 열처리 후에는 SiO$_2$가 첨가된 부분에서 비정상 입자가 생성되었고, 열처리 중에 연속적으로 성장하여 2 cm 크기 이상으로 성장하였다. 성장한 비정상 입자내부에는 (111) double twin 또는 single twin 등의 결함이 관찰되지 않아, 국부적으로 첨가된 SiO$_2$에 의하여 생성된 액상에 의하여 비정상 입자와 단결정이 성장하였다. 이러한 결과는 BaTiO$_3$계에서 액상 분포의 불균일으로 비정상 입성장이 유도될 수 있으며, 또한 비정상 입성장을 이용하여 쌍정면 결함을 포함하지 않는 cm크기의 BaTiO$_3$ 단결정을 제조할 수 있음을 보였다.

Keywords

References

  1. J. Am Ceram. Soc. v.54 no.1 Influence of Milled Powder Particle Size Distribution on the Microstructure and Electrical Properties of Sintered Mn-Zn Ferrite G.R.Chol
  2. Materials Science Monograms v.16 Microstructural Studies of Abnormal Grain Growth Development in Al₂O₃ S.J.Bennison;M.P.Harmer
  3. J. Am. Ceram. Soc. v.70 no.1 Control of Liquid-Phase-Enhanced Discontinuous Grain Growth in Barium Titanate D.F.K.Hennings;R.Janssen;P.J.S.Reynen https://doi.org/10.1111/j.1151-2916.1987.tb04847.x
  4. J. Am. Ceram. Soc. v.70 no.2 Exaggerated Grain Growth in Cemented Carbides due to Inhomogeneous Milling U.Seeker;H.E.Exner https://doi.org/10.1063/1.328266
  5. J. Am. Ceram. Soc. v.72 no.7 Mechanism for the Role of Magnesia in the Sintering of Alumina Containing Small amount of a Liquid Phase C.A.Bateman;S.J.Bennison;M.P.Harmer https://doi.org/10.1111/j.1151-2916.1989.tb09715.x
  6. Acta. Metall. v.13 no.3 On the Theory of Normal and Abnormal Grain Growth M.Hillert https://doi.org/10.1111/j.1151-2916.1989.tb09715.x
  7. Sci. Ceram. v.12 Recrystallization of Barium Titanate Ceramics D.Hennings https://doi.org/10.1016/0001-6160(65)90200-2
  8. J. Am. Ceram. Soc. v.73 no.2 Lanthanum-Magnesium and Lanthanum-Manganese Donor-Acceptor-Codoped Semiconducting Barium Titanate C.J.Ting;C.J.Peng;H.Y.Lu;S.T.Wu https://doi.org/10.1111/j.1151-2916.1990.tb06514.x
  9. Ceramic Transaction v.7 Discontinuous Grain Growth in Multiphase D.Kolar;C.A.Handwerker(ed.);J.E.Bledell(ed.)W.A.Kaysser(ed.) https://doi.org/10.1111/j.1151-2916.1990.tb06514.x
  10. J. Eur. Ceram. Soc. v.17 Effect of SiO₂ and TiO₂ Addition on the Exaggerated Grain Growth of BaTiO₃ Y.S.Yoo;H.Kim;D.Y.Kim https://doi.org/10.1016/S0955-2219(96)00134-3
  11. J. Eur. Ceram. Soc. v.20 no.6 Effect of Sintering Temperature on the Secondary Abnormal Grain Growth of BaTiO₃ H.Y.Lee;J.S.Kim;N.M.Hwang;D.Y.Kim https://doi.org/10.1016/S0955-2219(96)00134-3
  12. J. Am. Ceram. Soc. v.83 no.2 Growth of BaTiO₃ Seed Grains by the Twin-Plane Reentrant Edge Mechanism M.K.Kang;Y.S.Yoo;D.Y.Kim https://doi.org/10.1016/S0955-2219(99)00197-1
  13. J. Am. Ceram. Soc. v.85 no.4 Effecto Twin-Plane Reentrant Edge on the Coarsening Behavior of BaTiO₃ H.Y.Lee;J.S.Kim;D.Y.Kim https://doi.org/10.1111/j.1151-2916.2000.tb01201.x
  14. J. Eur. Ceram. Soc. v.17 Fabrication of BaTiO₃ Single Crystals by Using the Exaggerated Grain Growth Method Y.S.Yoo;M.K.Kang;J.H.Han;H.Kim;D.Y.Kim https://doi.org/10.1111/j.1151-2916.2002.tb00202.x
  15. J. Eur. Ceram. Soc. v.20 no.10 Fabrication of BaTiO₃ Single Crystals Using Secondary Abnormal Grain Growth H.Y.Lee;J.S.Kim;D.Y.Kim https://doi.org/10.1016/S0955-2219(97)00017-4
  16. Piezoelectric Single Crystals and their Application Solid-State Single Crystal Growth (SSCG) Method: A Cost-Effective Way of Growing Piezoelectric Single Crystals H.Y.Lee;S.Trolier-McKinstry(ed.);Y.Yamashita(ed.);L.E.Cross(ed.) https://doi.org/10.1016/S0955-2219(00)00030-3
  17. J. Am. Ceram. Soc. v.74 no.8 Phase Relations in the Barium Titanate-Titanium Oxide System K.W.Kirby;B.A.Wechsler https://doi.org/10.1111/j.1151-2916.1991.tb07797.x
  18. J. Am. Ceram. Soc. v.38 no.11 Phase-Equilibrium in the System BaTiO₃-SiO₂ D.E.Rase;R.Roy https://doi.org/10.1111/j.1151-2916.1991.tb07797.x
  19. J. Kor. Ceram. Soc. v.36 no.12 Secondary Abnormal Grain Growth and (III) Twin Boundaries in BaTiO₃ J.S.Kim;J.B.Lee;T.M.Heo;H.Y.Lee;D.Y.Kim https://doi.org/10.1111/j.1151-2916.1955.tb14562.x
  20. J. Appl. Phys. v.51 no.8 Sintering and Varistor Characteristics of ZnO-Bi₂O₃ Ceramics J.Wong