콘크리트학회논문집 (Journal of the Korea Concrete Institute)

  • 제24권3호
  • /
  • Pages.225-232
  • /
  • 2012
  • /
  • 1229-5515(pISSN)
  • /
  • 2234-2842(eISSN)
한국콘크리트학회 (Korea Concrete Institute)
권호 표지
DOI QR코드

DOI QR Code

전단 보강되지 않은 실규모 순환 잔골재 콘크리트 보의 전단성능

Shear Performance of Full-Scale Recycled Fine Aggregate Concrete Beams without Shear Reinforcement

  • Lee, Young-Oh (Dept. of Architectural Engineering, Chungnam National University) ;
  • Yun, Hyun-Do (Dept. of Architectural Engineering, Chungnam National University)
  • 투고 : 2011.06.04
  • 심사 : 2012.03.16
  • 발행 : 2012.06.30
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

이 연구는 순환잔골재를 사용한 콘크리트의 전단거동을 평가하고자 하였다. 추가적으로 순환굵은골재를 현행규준식 및 제안식과 비교/분석하였다. 동일한 압축강도를 갖는 5개의 실험체를 계획하였으며 각 실험체는 순환잔골재치환율(0%, 30%, 60%, 70%, 100%)을 변수로 계획하였으며 전단철근은 보강하지 않았다. 실험에 사용한 순환잔골재는 흡수율과 비중을 만족하는 골재를 사용하였다. 사용한 골재 중 70% 치환한 실험체의 경우 저품질의 순환잔골재를 사용하였다. 실험은 하중-변위관계, 전단변형, 경사균열하중, 균열패턴, 최대전단강도, 파괴모드를 분석하여 평가하였다. 실험 결과 순환잔골재를 사용한 철근콘크리트 보의 전단거동은 천연골재와 비교하여 전반적으로 큰 차이를 보이지 않았으나, 전단에 관한 규준식 및 제안식과 비교한 결과 순환잔골재를 사용한 철근콘크리트 보의 경우 규준식 수정을 통한 새로운 제안식이 필요할 것으로 판단된다.

This paper presents the test results on the shear performance of large-size reinforced concrete beams using recycled fine aggregate to evaluate its applicability to structural concrete. The performance of these beams is compared to that of similar beams casted with natural coarse and fine aggregates. All of the beam specimens without shear reinforcement had $400mm{\times}600mm$ rectangular cross section and a shear span ratio (a/d) of 5.0. Five concrete mixtures with different replacement levels of recycled fine aggregates (0, 30, 60, 70 and 100%) were used to obtain a nominal concrete compressive strength of 28MPa. The test results of load-deflection curve, shear deformation, diagonal cracking load, crack pattern, ultimate shear strength, and failure mode are examined and compared. In addition, code and empirical equations from KCI, JSCE, CSA, Zsutty, and MCFT were considered to evaluate the applicability of these equations for predicting shear strength of reinforced concrete beam with recycled fine aggregate. The results showed that the overall shear behavior of reinforced concrete beams incorporating less than 60% recycled fine aggregate was comparable with that of conventional concrete beam. The MCFT gave good prediction and other code equations were conservative in predicting the shear strength of the tested beams. The beam specimens with replacement of 70 and 100% of natural fine aggregates by recycled fine aggregates showed different failure mode than other tested beams.

키워드

참고문헌

  1. Ghaffar, A., Javed, A., Rehman, H. ur, Ahmed, K., and Ilyas, M., "Development of Shear Capacity Equations for Rectangular Reinforced Concrete Beams," Pak. J. Engg. & Appl. Sci., Vol. 6, 2010, pp. 1-8.
  2. Gonzalez, B. and Martinez, F., "Shear Strength of Concrete with Recycled Aggregates," Proceeding of the International RILEM Conference, Barcelona, Spain, 2004, pp. 619-628.
  3. Sogo, M., Sogabe, T., Maruyama, I., Sato, R., and Kawai, K., "Shear Behavior of Reinforced Recycled Concrete Beams," Proceeding of the International RILEM Conference, Barcelona, Spain, 2004, pp. 610-618.
  4. 고경택, 류금성, 한천구, 윤기원, 이장화, "부순모래를 사용한 콘크리트의 특성,"한국콘크리트학회 전문위원회 연구발표집, 2006, pp. 27-47.
  5. 건설교통부, "순환골재 콘크리트의 구조기준 설정연구," 2005 첨단도시개발사업 제3차년도 중간보고서, pp. 11-47.
  6. 국토해양부 제정 콘크리트구조설계기준, 한국콘크리트학회, 2007, 328 pp.
  7. JSCE, "Japan Concrete Specification," Tech. Rep., Japan Society of Civil Engineers in Japanese, 1999.
  8. CSA Committee A23.3-04, Design of Concrete Structures for Buildings CAV3-A23.3-04, Canadian Standards Association, Canada, 2004, 232 pp.
  9. Zsutty, T. C., "Shear Strength Prediction for Separate Categories of Simple Beam Test," ACI Journal, Vol. 68, No. 2, 1971, pp. 138-143.
  10. Vecchio, F. J. and Collins, M. P., "The Modified Compression- Field Theory for Reinforced Concrete Elements Subjected to Shear," ACI Journal, Vol. 83, No. 2, 1986, pp. 219-231.
  11. 전소진, 이우진, 김두식, 서수연, 윤승조, "잔골재와 굵은 골재를 산업폐기물로 치환한 보의 전단 거동에 관한 연구," 대한건축학회 학술발표 논문집, 25권, 1호, 2005, pp. 333-336
  12. 이원석 외 1인, "순환골재를 사용한 철근콘크리트 보의 전단성능," 대한건축학회 논문집, 23권, 4호, 2007, pp. 19-26.
  13. Bazant, P. Z. and Kazemi, T, "Size Effect on Diagonal Shear Failure of Beams without Strriups," ACI Structural Journal, No. 88-S29, 1991, pp. 268-276.
  14. ACI-ASCE Committee 426, Suggested Revisions to Shear Provisions for Building Codes, American Concrete Institute, Detroit, 1978, pp. 1191-1187.
  15. ACI Committes 318-08, Building Code Requirements for Structural Concrete(ACI 318M-08) and Commentary, American Cconcrete Institute, 2008, 473 pp.
  16. 이경희, "재생골재를 사용한 철근콘크리트 보의 전단성 능과 휨성능에 관한 실험적 연구," 충남대학교 대학원, 석사학위 논문, 2002.
  17. 이원석, 윤현도, 김선우, 최기선, 유영찬, 김긍환, "순환굵은골재 치환율에 따른 전단보강되지 않은 철근콘크리트 보의 전단강도특성," 대한건축학회 논문집, 23권, 10 호, 2007, pp. 3-10.
  18. 市川信雄, 菊池雅史, 恩川和博, "再生骨材を混合したコソくㅡリトる部材の力學的特性に關する檢討," 日本建築學會大會學術講演梗槪集, 1993, pp. 85-88.
  19. Etxeberria, M., Mari, A. R., and Vázquez, E., "Recycled Aggregate Concrete as Structural Material," Materials and Structures, Vol. 40, No. 5, 2007, pp. 529-541. https://doi.org/10.1617/s11527-006-9161-5
  20. Building Contrators Society of Japan, "Proposed standard for the use of recycled aggregate and recycled aggregate concrete," Committe on Disposal and Reuse of Construction Waste, 1977.

피인용 문헌

  1. Shear strength of reinforced recycled aggregate concrete beams without shear reinforcements vol.23, pp.1, 2017, https://doi.org/10.3846/13923730.2014.976257