The Transactions of the Korean Institute of Power Electronics (전력전자학회논문지)

The Korean Institute of Power Electronics (전력전자학회)
권호 표지
DOI QR코드

DOI QR Code

Switch Open Circuit Fault Detection for Power Conversion System of Hybrid Electric Vehicles

전기자동차용 전력변환시스템의 스위치 개방형 고장 검출

  • Received : 2013.01.16
  • Accepted : 2013.02.19
  • Published : 2013.04.20
Download PDF
⟨ Previous Next ⟩

Abstract

Recently, the demand for fuel efficient electric vehicles (EVs) and hybrid electric vehicles (HEVs) has been growing globally. Due to the increased number of switching devices in the electrified vehicles, the probability of the semiconductor device failure is much higher than in other application areas. A sudden failure in one of the power switches and insufficient power management ability in the systems not only decreases system performance, but also leads to critical safety problems. In this paper, novel switch open circuit fault detection method is proposed, and the proposed approach is verified by experiments.

Keywords

References

  1. A. Emadi, K. Rajashekara, S. S. Williamson, and S. M. Lukic, "Topological overview of hybrid electric and fuel cell vehicular power system architectures and configurations," IEEE Trans. Veh. Technol., Vol. 54, No. 3, pp. 763-770, May 2005. https://doi.org/10.1109/TVT.2005.847445
  2. A. Emadi, K. Rajashekara, S. S. Williamson, and S. M. Lukic, "Topological overview of hybrid electric and fuel cell vehicular power system architectures and configurations," IEEE Trans. on Vehicular Technology, Vol. 54, No. 3, pp. 763-770, May 2005. https://doi.org/10.1109/TVT.2005.847445
  3. M. A. Awadallah, "Detection of stator short circuits in VSI-fed brushless DC motors using wavelet transform," IEEE Trans. Ener. Conv., Vol. 21, No. 1, pp. 1-8, 2006. https://doi.org/10.1109/TEC.2005.847964
  4. D. Kastha and B. K. Bose, "Investigation of fault modes of voltage-fed inverter system for induction motor drive," IEEE Trans. Ind. Applicat., Vol. 30, pp. 1994.
  5. R. Peuget, S. Courtine, and J. P. Rognon, "Fault detection and isolation on a pwm inverter by knowledge-based model," IEEE Trans. Ind. Applicat., Vol. 34, pp. 1998.
  6. S. Bolognani, M. Zordan, and M. Zigliotto, "Experimental fault-tolerant control of pmsm drive," IEEE Trans. Ind. Electron., Vol. 47, pp. 2000.
  7. Khan, M. Rahman, M.A., "Development and Implementation of a Novel Fault Diagnostic and Protection Technique for IPM Motor Drives, Industrial Electronics", IEEE Transactions on, Vol. 56, No. 1, pp. 85-92, Jan. 2009. https://doi.org/10.1109/TED.2008.2007830
  8. Karimi, S. Gaillard, A. Poure, P. Saadate, S., "FPGA-Based Real-Time Power Converter Failure Diagnosis for Wind Energy Conversion Systems," Industrial Electronics, IEEE Transactions on, Vol. 55, No. 12, pp. 4299-4308, Dec. 2008. https://doi.org/10.1109/TIE.2008.2005244
  9. T. Kim, W. Lee, and D. Hyun, "Detection Method for Open-Circuit Fault in Neutral-Point-Clamped Inverter Systems," Industrial Electronics, IEEE Transactions on, Vol. 56, No. 7, pp. 2754-2763, July 2009. https://doi.org/10.1109/TIE.2009.2019775
  10. Hag-Wone Kim, "Simple Switch Open Fault Detection Method for Voltage Source Inverter," The Trans. of the KIPE, Vol. 13, No. 6, pp. 430-438, 2008.
  11. Sung-Guk Ahn, Byoung-Gun Park, Rae-Young Kim, Dong-Seok Hyun, "Fault Diagnosis Scheme for Open-Phase Fault of Permanent Magnet Synchronous Motor Drive using Extended Kalman Filter," The Trans. of the KIPE, Vol. 16, No. 2, pp. 191-198, 2011. https://doi.org/10.6113/TKPE.2011.16.2.191
  12. Raphael Peuget, Stephane Courtine and Jean-Pierre Rignon, "Fault Detection and Isolation on a PWM inverter by Knowledge-Based Model," IEEE Trans. on Industry Applications, Vol. 34, No. 6, Nov. 1998.
  13. Hee-Keun Shin, Byoung-Woong An, Hag-Wone Kim, Kwan-Yuhl Cho, Shin-Myung Jung, "Switch Open Fault Detection and Tolerant Operation Method for Three Phase PWM Rectifier," The Trans. of the KIPE, No. 17, No. 3, pp. 266-273, 2012. https://doi.org/10.6113/TKPE.2012.17.3.266