Journal of the Korean Society of Food Science and Nutrition (한국식품영양과학회지)

The Korean Society of Food Science and Nutrition (한국식품영양과학회)
권호 표지
DOI QR코드

DOI QR Code

Stability of Oil-in-Water Emulsions with Different Saturation Degrees from Beef Tallow Alcoholysis Products

우지 Alcoholysis 반응물을 이용한 Oil-in-Water Emulsion의 포화도에 따른 산화특성 및 안정성 연구

  • Zhang, Hua (Dept. of Food Science and Technology, Chungnam National University) ;
  • Lee, Young-Hwa (Rural Development Administration) ;
  • Shin, Jung-Ah (Dept. of Food Science and Technology, Chungnam National University) ;
  • Lee, Ki-Teak (Dept. of Food Science and Technology, Chungnam National University) ;
  • Hong, Soon-Teak (Dept. of Food Science and Technology, Chungnam National University)
  • Received : 2013.02.06
  • Accepted : 2013.03.22
  • Published : 2013.06.30
Download PDF
⟨ Previous Next ⟩

Abstract

In this study, methyl esters with different saturated fatty acids (SFA) were prepared by urea fractionation to make an oil-in-water emulsion. Emulsion characteristics (emulsion stability and oxidative stability) of the methyl ester emulsion were then studied at different percentages of methyl ester saturation (5, 28, 39, 50, and 72%, termed ${\Sigma}$SFA5, ${\Sigma}$SFA28, ${\Sigma}$SFA39, ${\Sigma}$SFA50, and ${\Sigma}$SFA72, respectively). The stability of emulsions (ES) with different SFA content was 46.0 (${\Sigma}$SFA5), 39.5 (${\Sigma}$SFA28), 32.7 (${\Sigma}$SFA39), 32.6 (${\Sigma}$SFA50), and 27.3 (${\Sigma}$SFA72). Results from Turbiscan showed that creaming or clarification, based on the backscattering intensity, was more pronounced with increases in the saturation degree of the emulsion. These results implied that the emulsions with lower saturation were more stable. During 30 days of storage, the lipid peroxide value increased for all emulsions, with the increase less pronounced with the increasing saturation of the emulsion; 1.880 (${\Sigma}$ SFA5), 1.267 (${\Sigma}$SFA28), 1.062 (${\Sigma}$SFA39), 0.342 (${\Sigma}$SFA50) and 0.153 (${\Sigma}$SFA72) mg $H_2O_2/mL$ emulsion. In addition, thiobarbituric acid reactive substances (TBARS) values were significantly lower in emulsions with high saturation (4.419 mg for ${\Sigma}$SFA50 and 4.226 mg for ${\Sigma}$SFA72) than emulsions with low saturation (6.229 mg for ${\Sigma}$SFA5, 6.801 mg for ${\Sigma}$SFA28 and 6.246 mg for ${\Sigma}$SFA39). In conclusion, the emulsions with a higher saturation degree of methyl esters showed lower emulsion stability but better oxidation stability.

본 연구는 urea fractionation을 통하여 포화도 함량이 5.8%, 28.4%, 39.2%, 50.7%, 72.3%인 우지 alcoholysis 반응물을 제조하고, 이를 유상(oil phase)으로 ultrasonic processor 및 고압균질기를 이용하여 emulsion을 제조한 후 이에 대한 유화 안정성과 산화 안정성을 실험하였다. 유화 안정성(ES)을 관찰한 결과 ES값은 46.0(${\Sigma}$SFA5), 39.5(${\Sigma}$SFA28), 32.7(${\Sigma}$SFA39), 32.6(${\Sigma}$SFA50) 및 27.3(${\Sigma}$SFA72)로써 포화도가 낮은 emulsion일수록 높은 안정성을 보였으며, Turbiscan을 이용하여 시료 emulsion의 creaming 및 clarification 특성을 조사한 결과도 ES 결과와 유사하게 나타났다. 고압균질기로 제조한 emulsion 시료에 대하여 30일간 산화특성 및 안정성 연구를 진행한 결과, 제조한 emulsion의 hydroperoxides 함량이 1.880(${\Sigma}$SFA5), 1.267(${\Sigma}$SFA28), 1.062(${\Sigma}$SFA39), 0.342(${\Sigma}$SFA50) 및 0.153(${\Sigma}$SFA72)mg $H_2O_2/mL$로 서로 유의적 차이(p<0.05)를 나타내면서 불포화도가 높은 emulsion 시료일수록 hydroperoxide의 함량이 높았고, TBARS 값은 저장 30일에 6.229(${\Sigma}$SFA5), 6.801(${\Sigma}$SFA28), 6.246(${\Sigma}$SFA39), 4.419(${\Sigma}$SFA50) 및 4.226(${\Sigma}$SFA72) mg TBA/mL로 ${\Sigma}$SFA50과 ${\Sigma}$SFA72가 다른 emulsion 시료보다 유의적으로(p<0.05) 낮은 값을 보이며 산화 안정성이 우수하였다.

Keywords

References

  1. Nisisako T. 2008. Microstructured devices for preparing controlled multiple emulsions. Chem Eng Technol 31:1091-1098. https://doi.org/10.1002/ceat.200800119
  2. Tadros T, Izquierdo P, Esquena J, Solans C. 2004. Formation and stability of nano-emulsions. Adv Colloid Interface Sci 108-109: 303-318. https://doi.org/10.1016/j.cis.2003.10.023
  3. Aruoma OI. 1998. Free radicals, oxidative stress and antioxidants in human health and disease. J Am Oil Chem Soc 75: 199-212. https://doi.org/10.1007/s11746-998-0032-9
  4. McCLements DJ, Deker EA. 2000. Lipid oxidation in oil-inwater emulsions: lmpact of molecular environment on chemical reactions in heterogeneous food systems. J Food Sci 65: 1270-1282. https://doi.org/10.1111/j.1365-2621.2000.tb10596.x
  5. McClements DJ. 2004. Food emulsions: principles, practice and techniques. 2nd ed. CRC press, Boca Raton, FL, USA. p 336.
  6. Loh SK, Chew SM, Choo YM. 2006. Oxidative stability and storage behavior of fatty acid methyl esters derived from used palm oil. J Am Oil Chem Soc 83: 947-952. https://doi.org/10.1007/s11746-006-5051-9
  7. Zhang Y, Yang L, Zu Y, Chen X, Wang F, Liu F. 2010. Oxidative stability of sunflower oil supplemented with carnosic acid compared with synthetic antioxidants during accelerated storage. Food Chem 118: 656-662. https://doi.org/10.1016/j.foodchem.2009.05.038
  8. Di Mattia CD, Sacchetti G, Mastrocola D, Pittia P. 2009. Effect of phenolic antioxidants on the dispersion state and chemical stability of olive oil O/W emulsions. Food Res Int 42: 1163-1170. https://doi.org/10.1016/j.foodres.2009.05.017
  9. Tadros T. 2004. Application of rheology for assessment and prediction of the long-term physical stability of emulsions. Adv Colloid Interface Sci 108-109: 227-258. https://doi.org/10.1016/j.cis.2003.10.025
  10. Gu YS, Decker EA, McClements DJ. 2005. Influence of pH and carrageeenan type on properties of ${\beta}$-lactoglobulin stabilized oil-in-water emulsion. Food Hydrocolloids 19:83-91. https://doi.org/10.1016/j.foodhyd.2004.04.016
  11. Hong ST. 2008. Changes in the stability properties of methylcellulose emulsions as affected by competitive adsorption between methylcellulose and tween 20. J Korean Soc Food Sci Nutr 37: 1278-1286. https://doi.org/10.3746/jkfn.2008.37.10.1278
  12. Dickinson E, Williams A. 1994. Orthokinetic coalescence of protein-stabilized emulsions. Colloids Surf A 88: 317-326. https://doi.org/10.1016/0927-7757(94)02861-3
  13. Lin CC, Lin HY, Chen HC, Yu MW, Lee MH. 2009. Stability and characterisation of phospholipid-based curcumin-encapsulated microemulsions. Food Chem 116: 923-928. https://doi.org/10.1016/j.foodchem.2009.03.052
  14. Abdullah BM, Salimon J. 2010. Optimization of process variables using D-optimal design for separating linoleic acid in J atropha curcas seed oil by urea complex fractionation. Biotechnology 9: 362-367. https://doi.org/10.3923/biotech.2010.362.367
  15. Jeon MS, Lee KT. 2009. Enzymatic synthesis of diacylglycerol oil from glyceryl mono-oleate and conjugated linoleic acid using a stirred-batch type reactor. Korean J Food Preserv 16: 246-252.
  16. Kim YC, Han KH, Ryu JG. 2004. A study on the various characteristics of ultrasonic-energy-added w/o type emulsified fuel (II)-attaching importance to micro-explosion of droplet and chemical characteristics. J Ilass-Korea 9:29-34.
  17. Zhang H, Shin JA, Lee KT. 2011. Reduction of saturated fatty acid methyl esters of biodiesel produced from beef tallow by acetone fractionation. J Korean Oil Chem Soc 28:472-481.
  18. Hong ST. 2008 Competitive displacement of methylcellulose from oil-water interface by various emulsifiers. J Korean Soc Food Sci Nutr 37: 1271-1277. https://doi.org/10.3746/jkfn.2008.37.10.1271
  19. Lima AS, Alegre RM. 2009. Evaluation of emulsifier stability of biosurfactant produced by Saccharomyces lipolytica CCT-0913. Braz Arch Biol Technol 52: 285-290. https://doi.org/10.1590/S1516-89132009000200004
  20. Park JS, Lee YJ, Chun SS. 2010. Quality characteristics of sponge cake added with banana powder. J Korean Soc Food Sci Nutr 39: 1509-1515. https://doi.org/10.3746/jkfn.2010.39.10.1509
  21. McClements DJ. 2004. Food emulsions: principles, practice and techniques. 2nd ed. CRC press, Boca Raton, FL, USA. p 175-232, 461-515.
  22. Mei L, McClements DJ, Decker EA. 1999. Lipid oxidation in emulsions as affected by charge status of antioxidants and emulsion droplets. J Agric Food Chem 47: 2267-2273. https://doi.org/10.1021/jf980955p
  23. McDonald RE, Hultin HO. 1987. Some characteristics of the enzymatic lipid-peroxidation system in the microsomal fraction of flounder skeletal muscle. J Food Sci 52: 15-21. https://doi.org/10.1111/j.1365-2621.1987.tb13964.x
  24. Guillen MD, Ruiz A. 2005. Monitoring the oxidation of unstaturated oils and formation of oxygenated aldehydes by proton NMR. Eur J Lipid Sci Technol 107: 36-47. https://doi.org/10.1002/ejlt.200401056
  25. Lee HJ, Bae JS, Lee ES, Kang HC, Lee KT, Hong ST. 2012. Emulsifying properties of surface-active substances from defatted rice bran by supercritical carbon dioxide. Food Eng Prog 16: 172-179.
  26. Lee JY, Mok C. 2010. Dispersion stability determination of Saengshik beverage by optical methods. Food Eng Prog 14: 41-48.
  27. Jafari SM, He Y, Bhandari B. 2007. Production of sub-micron emulsions by ultrasound and microfluidization techniques. J Food Eng 82: 478-488. https://doi.org/10.1016/j.jfoodeng.2007.03.007
  28. Roozen JP, Frankel, EN, Kinsella JE. 1994. Enzymic and autoxidation of lipids in low fat foods: model of linoleic acid in emulsified hexadecane. Food Chem 50: 33-38. https://doi.org/10.1016/0308-8146(94)90089-2

Cited by

  1. 식품 유화액 시스템에서 락토페린의 유화 특성 vol.30, pp.4, 2013, https://doi.org/10.12925/jkocs.2013.30.4.779