한국건축시공학회지 (Journal of the Korea Institute of Building Construction)

  • 제17권3호
  • /
  • Pages.269-277
  • /
  • 2017
  • /
  • 1598-2033(pISSN)
  • /
  • 2233-5706(eISSN)
한국건축시공학회 (The Korean Institute of Building Construction)
권호 표지
DOI QR코드

DOI QR Code

콘크리트 폐기물에서 분리된 페이스트를 활용한 고화재 기술개발 기초연구

Recycling Waste Paste from Concrete for Solidifying Agent

  • 투고 : 2017.03.28
  • 심사 : 2017.05.24
  • 발행 : 2017.06.20
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

본 연구에서는 원전 콘크리트로부터 분리된 페이스트 미분말을 이용 방사성폐기물 처분용 고화재로 활용하기 위하여 기초 특성을 검토하고자 하였다. 실험 결과 수화반응한 페이스트는 시멘트보다 비중이 낮고 수화회복을 위한 소성과정에서 온도증가에 따라 비중이 다르게 나타나 그에 따른 부피도 고려되어야 할 것으로 판단된다. 수화회복을 위한 소성온도에서 압축강도가 가장 우수한 온도조건은 $600^{\circ}C$로 나타났으며, $700^{\circ}C$ 이상에서는 CaO의 생성량이 과도하여 높은 수화열, 유동성 저하 및 낮은 강도가 발현되는 것을 확인하였다. 따라서 본 연구 범위 내에서 고화재로 활용 가능한 적정 수화회복 온도는 $600^{\circ}C$로 판단되며 폐콘크리트 페이스트가 적정한 열처리를 거치는 경우 방사성 폐기물 고화재료로서 활용될 수 있는 가능성을 보였다는 점에 의의를 둔다.

In this work, as a preliminary experimental works, which focuses on utilizing separated pastes from activated (or radioactive) concrete as solidifying agents for radioactive waste immobilization, were performed. It was found that density of hydrated cement paste, which was lower than that of ordinary portland cement, increased as temperature for heat treatment increased. Highest compressive strength was observed with the specimens that was heat treated at $600^{\circ}C$. However, heat treatment over $700^{\circ}C$ showed higher CaO content that caused higher heat of hydration after in contact with water, lows of workability, and lower strength. Based on experimental results, it is suggested that $600^{\circ}C$ heat treatment is more appropriate for waste cement paste to be used as a solidifying agent.

키워드

참고문헌

  1. Sasaki T, Sone T, Koyama H, Yamaguchi H. Steam -assisted pyrolysis system for decontamination and volume reduction of radioactive organic waste. Journal of Nuclear Science and Technology. 2009 Mar;46(3):232-38. https://doi.org/10.1080/18811248.2007.9711526
  2. Sawada K, Uruga K, Koyama T, Shimada T, Mori Y, Enokida Y, Yamamoto I. Stoichiometric relation for extraction of uranium from UO2 powder using TBP complex with HNO3 and H2O in supercritical CO2. Journal of Nuclear Science and Technology. 2005 Mar;42(3):301-4. https://doi.org/10.1080/18811248.2005.9726394
  3. COX EJ, GARDE R. Decontamination of concrete surfaces at the Los Alamos Scientific Laboratory. In: Proc. DOE Concrete Decontamination Workshop; 1980 May 28-29; Battelle Conference Center. Seattle(WA): the Los Alamos Scientific Laboratory; 1980. p. 109-23.
  4. Koga Y, Inoue T, Tateyashiki H, Okamoto M, Asano T. A process for separating aggregate from concrete waste during the dismantlement of nuclear power plants. Journal of Hoshasei Haikibutsu Kenkyu. 1997;3(2):17-25.
  5. Cha GY, Kim SY, Lee JM, Kim YS. The effects of impurity composition and concentration in reactor structure material on neutron activation inventory in pressurized water reactor. Journal of Nuclear Fuel Cycle and Waste Technology(JNFCWT). 2016 Jun;14(2):91-100. https://doi.org/10.7733/jnfcwt.2016.14.2.91
  6. Cornelissen HAW. Test installation for Volume Reduction of Contaminated/Activated Concrete. KEURING VAN ELECTROTECHNISCHE MATERIALEN(KEMA, Nerland);1995. Report 40913-KET/R&B 95-4078.
  7. Binkhorst IP. Rebondin intermediate Report part 1 and part 2. KEURING VAN ELECTROTECHNISCHE MATERIALEN(KEMA, Nerland);1997. Report 00332-KST/MAT 97-6632.
  8. Min BY, Park JW, Choi WK, Lee KW. Separation of radionuclide from dismantled concrete waste. Journal of the Korean Radioactive Waste Society. 2009 Jun;7(2):79-86.
  9. Binkhorst IP, Cornelissen HAW. Technology for reuse of contaminated concrete constituents. Vienna(Austria): International Atomic Energy Agency(Austria); 1998 Jun. 187 p. Report No.: IAEA-TECDOC-1022.
  10. Ahn JC, Lee JH, Kang BH. Properties of recycle cement made of cementitious powder from concrete waste by conditions of burning. Journal of Architectural Institute of Korea. 2013 Nov;19(11):109-12.
  11. Do JB, Cho HD, Jaung JD. The research for present status of production and utilization of recycled aggregate. The Regional Association of Architectural Institute of Korea. 2012 Dec;8(1):487-8.
  12. Lee HH. Production Method Review of Recycled Aggregates. Proceeding of Korea Institute for Structural Maintenance and Inspection; 2015 Apr 2-4; Busan, Korea. Seoul (Korea): Korea Institute for Structural Maintenance and Inspection; 2015. p. 621-2.
  13. Song H, Shin HU, Lee JK, Chu YS, Park DC. Image and phase analysis of low carbon type recycled cement using waste concretw powder. Journal of Korean Recycled Construction Resources Institute. 2014 Dec;2(4):314-20. https://doi.org/10.14190/JRCR.2014.2.4.314
  14. Jang JH, Kim YR, Choi SJ, Choi HY, Kim MH, Kim MH. A study on the fundamental properties and application as cementious admixture by heating temperature of recycled powder. Proceeding of Korea Concrete Institute; 2001 May 12; Anseong, Korea. Seoul (Korea): Korea Concrete Institute; 2001. p. 635-40.
  15. Cho MC, Park TS, Chu YS, Hwang HZ. A study on the development of recycling cement using the waste concrete powder. Proceeding of Korea Concrete Institute; 2002 May 12; Chungju, Korea. Seoul (Korea): Korea Concrete Institute; 2002. p. 137-42.
  16. Xinwei M, Zhaoxiang H, Xueying L. Reactivity of dehydrated cement paste from waste concrete subjected to heat treatment. Coventry University and The University of Wisconsin Milwaukee Centre for By-products Utilization Conference Proceeding Second International Conference on Sustainable Construction Materials and Technologies; 2010 Jun 28-30; Ancona, Italy. West Midlands (United Kingdom): Sustainable Construction Materials and Technologies; 2010. p. 175-80.
  17. Letelier V, Tarela E, Munoz P, Moriconi G. Combined effects of recycled hydrated cement and recycled aggregates on the mechanical properties of concrete. Construction and Building Materials. 2017 Feb;132:365-75. https://doi.org/10.1016/j.conbuildmat.2016.12.010
  18. Hager I. Behaviour of cement concrete at high temperature. Bulletin of the Polish Academy of Sciences: Technical Sciences. 2013 Mar;61(1):145-54. https://doi.org/10.2478/bpasts-2013-0013