한국수소및신에너지학회논문집 (Transactions of the Korean hydrogen and new energy society)

  • 제30권5호
  • /
  • Pages.436-447
  • /
  • 2019
  • /
  • 1738-7264(pISSN)
  • /
  • 2288-7407(eISSN)
한국수소및신에너지학회 (The Korean Hydrogen and New Energy Society)
권호 표지
DOI QR코드

DOI QR Code

Pilot 순환유동층 연소장치에서의 목재펠릿과 아역청탄 혼소 특성

Characteristics of Co-Combustion of Wood Pellet with Sub-Bituminus Coal in A Pilot CFB Combustor

  • 김동원 (한국전력공사 전력연구원 발전기술연구소) ;
  • 박경일 (한국전력공사 전력연구원 발전기술연구소) ;
  • 이종민 (한국전력공사 전력연구원 발전기술연구소) ;
  • 배용채 (한국전력공사 전력연구원 발전기술연구소)
  • 투고 : 2019.10.10
  • 심사 : 2019.10.31
  • 발행 : 2019.10.31
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

The circulating fluidized bed boiler has an advantage that can burn a variety of fuels from low-grade fuel to coal. In this study, for the design of a circulating fluidized bed boiler using wood pellets, a circulating fluidized bed combustion test device using no external heater was manufactured and used. According to the increase of co-combustion rate with wood pellet, combustion fraction and heat flux by combustor height were measured and pollutant emission characteristics were analyzed. In terms of combustibility, the effect on primary and secondary air ratio were also studied. In addition, as a result of analysis of the effect of corrosive nanoparticles on the combustion of coal with wood pellets, it was confirmed that coal is mostly composed of Ca and S, whereas wood pellets are mostly composed of K, Cl, and Na.

키워드

참고문헌

  1. M. Conte, A. Iacobazzi, M. Ronchetti, and R. Vellone, "Hydrogen economy for a sustainable development : state of the art and tehchnol ogical perspectives", J. Power Sources, Vol. 100. 2001, pp. 171-187, doi: https://doi.org/10.1016/S0378-7753(01)00893-X.
  2. I. Barnes, "Operating Experience of Low Grade Fuels in Circulating Fluidized Bed Combustion (CFBC) boilers", IEA Clean Coal Centre, UK, 2015.
  3. H. R. David, "McCoy Power Reports 2019", McCoy, Singapore, 2019.
  4. J. M. Lee, D. W. Kim, J. S. Kim, J. G. Na, and S. H. Lee, "Co-combustion of Refused Derived Fuel with Korean Anthracite in a Commercial Circulating Fluidized Bed Boiler", Energy, Vol. 35, 2010, pp. 2814-2818, doi: https://doi.org/10.1016/j.energy.2010.03.008.
  5. D. W. Kim, J. M. Lee, J. S. Kim, and J. J. Kim, "Co-combustion of Korean Anthracite with Bituminus Coal in Two Circulating Fluidized Bed Combustors", Korean J. Chem. Eng. Vol. 24. 2007, pp. 461-465, doi: https://doi.org/10.1007/s11814-007-0080-0.
  6. H. Topal, A. T. Atimtay and A. Durmaz. "Olive cake combustion in a circulating fluidized bed.", Fuel, Vol. 82, No. 9, 2003, pp. 1049-1056, doi: https://doi.org/10.1016/S0016-2361(02)00404-0.
  7. A. T. Atimtay, H. Topal, "Co-combustion of olive cake with lignite coal in a circulating fluidized bed", Fuel, Vol. 83, No. 7-8, 2004, pp. 859-867, doi: https://doi.org/10.1016/j.fuel.2003.09.015.
  8. P. Gayan, J. Adanez, L. F. Diego, F. Garcia, A. Cabanillas, A. Bahillo, M. Aho, K. Veijonen, "Circulating fluidised bed co-combustion of coal and biomass". Fuel. Vol. 83, No. 3, 2004, pp. 277-286, doi: https://doi.org/10.1016/j.fuel.2003.08.003.
  9. J. J. Xie, X. M. Yang, T. L. Ding, W. L. Song, W. G. Lin, "Emissions of SO2, NO and N2O in a circulating fluidized bed combustor during co-firing coal and biomass", J. Environmental Sciences. Vol. 19, No. 1, 2007, pp. 109-116, doi: https://doi.org/10.1016/S1001-0742(07)60018-7.
  10. M. A., Youssef, S. S. Wahid, M. A. Mohamed, A. A. Askalany, "Experimental study on Egyptian biomass combustion in circulating fluidized bed". Applied Energy. Vol. 86, No. 12, 2009, pp, 2644-2650, doi: https://doi.org/10.1016/j.apenergy.2009.04.021.
  11. B. Leckner, L. E. Amand, K. Lucke, J. Werther, "Gaseous emissions from co-combustion of sewage sludge and coal/wood in a fluidized bed", Fuel. Vol. 83, No. 4-5, 2004, pp. 477-486. https://doi.org/10.1016/j.fuel.2003.08.006
  12. T. Saikaew, P. Supudommak, L. Mekasut, P. Piumsomboon, P. Kuchonthara, "Emission of NOx and N2O from cocombustion of coal and biomasses in CFB combustor", Int. J. Greenhouse Gas Control. Vol. 10. 2012, pp. 26-32. https://doi.org/10.1016/j.ijggc.2012.05.014
  13. B. Leckner, "Fluidized bed combustion: mixing and pollutant limitation", Prog. Energy Combust. Sci. Vol. 24. 1998, pp. 31-61. https://doi.org/10.1016/S0360-1285(97)00021-X
  14. F. Scala, P. Salatino, "Modelling fluidized bed combustion of high volatile solid fuels", Chemical Engineering science. Vol. 57. 2002, pp. 1175-1196. https://doi.org/10.1016/S0009-2509(02)00004-0
  15. Luecke, K., Hartge, E. U., Ragucci, R., Salatino, P., "'A 3-dimensional model of combustion in large-scale circulating fluidized bed boilers", Int. J. Chemical Reactor Engineering, Vol. 43. 2004, pp. 5738-5753. https://doi.org/10.1021/ie049729x
  16. P. Basu, "Circulating fluidized bed boilers", Springer, 2015, pp. 173-209.
  17. R. Solimense, A. Marzocchella, R. Ragucci, P. Salatino, "Laser diagnos and gas-mixing induced by bubble bursting at the surface of gas-fluidized beds", Chemical Engineering Science. Vol. 62. 2007, pp. 94-108. https://doi.org/10.1016/j.ces.2006.08.007