한국추진공학회지 (Journal of the Korean Society of Propulsion Engineers)

  • 제25권2호
  • /
  • Pages.12-23
  • /
  • 2021
  • /
  • 1226-6027(pISSN)
  • /
  • 2288-4548(eISSN)
한국추진공학회 (The Korean Society of Propulsion Engineers)
권호 표지
DOI QR코드

DOI QR Code

모델 가스터빈 연소기에서 인젝터 형태에 따른 종-방향 불안정성 특성에 관한 실험적 연구

An Experimental Study on Longitudinal Instability Characteristics with Injector Type in Model Gas Turbine Combustor

  • Ahn, Jihwan (School of Mechanical and Aerospace Engineering, Sunchon National University) ;
  • Kang, Yeonse (Department of Aerospace Engineering, Sunchon National University) ;
  • Lee, Keeman (School of Mechanical and Aerospace Engineering, Sunchon National University)
  • 투고 : 2020.07.10
  • 심사 : 2020.11.06
  • 발행 : 2021.04.30
PDF 다운로드
⟨ 이전 논문 다음 논문 ⟩

초록

이 연구에서는, 모델 가스 터빈 연소기에서 발생하는 저선회 인젝터와 강선회 인젝터의 열-음향불안정성을 비교하고 있다. 인젝터 형태에 다른 불안정한 거동의 비교를 위하여, 다양한 당량비와 연소실 길이의 광범위한 범위의 실험이 수행되었다. 실험 결과, 연소기에서 발생된 대부분의 불안정성은 종-방향 불안정성이라는 것이 확인되었다. 또한, 강선회 인젝터가 저선회 인젝터에 비하여 더 넓은 연소실 길이 영역에서 강한 연소 불안정성이 발생됨이 발견되었다. 저선회 인젝터의 막힘률은 전체적인 거동 측면에서 큰 의미를 보이지 않았다. 또한, 인젝터의 형태에 무관하게 연소실 길이가 동일한 경우에 연소 불안정성이 발생한 경우에는 불안정성의 특성이 유사함이 발견되었다.

In this study, the combustion instability characteristics of low-swirl injector and high-swirl injector is compared by model gas turbine combustor. To compare of unstable behavior in high-swirl injector and low-swirl injector, we performed lots of measurement of combustion instability, with variable of equivalence ratio, combustor length and injector type. The results shown that longitudinal instability occur dominantly in model gas turbine combustor. In addition, it was found that high-swirl injector has more wide range of unstable regime than low-swirl injector. The blockage ratio what one of a parameter in low-swirl injector has not much effected in aspects of overall combustor behavior. Also, revealed that combustion instability occurred in the same combustor length has same properties, regardless of the injector type.

키워드

과제정보

본 연구는 산업통산자원부(MOTIE)와 한국에너지기술평가원(KETEP)의 지원을 받아 수행한 연구 과제입니다.(No. 20181110100290)

참고문헌

  1. Cheng, R.K., "Velocity and Scalar Characteristics of Premixed Turbulent Flames Stabilized by Weak Swirl," Combustion and Flame, Vol. 101, No. 1-2, pp. 1-14, 1995. https://doi.org/10.1016/0010-2180(94)00196-Y
  2. Cheng, R.K., Yegian, D.T., Miyasato M.M., Samuelsen, G.S., Benson, C.E., Pellizzari, R. and Loftus, P., "Scaling and development of low-swirl burners for low-emission furnaces and boilers," Proceedings of the Combustion Institute, Vol. 28, Issue 1, pp. 1305-1313, 2000. https://doi.org/10.1016/S0082-0784(00)80344-6
  3. Plessing, T., Kortschik, C., Peters, N., Mansour, M.S. and Cheng, R.K., "Measurements of the Turbulent Burning Velocity and the Structure of Premixed Flames on a Low-Swirl Burner," Proceedings of the Combustion Institute, Vol. 28, No. 1, pp. 359-366, 2000. https://doi.org/10.1016/S0082-0784(00)80231-3
  4. Littlejohn, D. and Cheng, R.K., "Fuel effects on a low-swirl injector for lean premixed gas turbines," Proceedings of the Combustion Institute, 31, pp. 3155-3162, 2007. https://doi.org/10.1016/j.proci.2006.07.146
  5. Cheng, R.K., Low swirl combustion, The Gas Turbine Handbook, pp. 241-255, 2006.
  6. Jeong, H. and Lee, K., "Effect of Swirl Angles and Combustion Characteristics of low Swirl Model Combustor," Journal of the Korean Society of Propulsion Engineers, Vol. 20, No. 4, pp. 40-49, 2016. https://doi.org/10.6108/KSPE.2016.20.4.040
  7. Jeong, H. Kang, K. and Lee, K., "A study on the combustion characteristics with hydrogen contents of SNG fuel in low-swirl combustor," Trans. of Korean Hydrogen and New Energy Society, Vol. 28, No. 2, pp. 181-189, 2017. https://doi.org/10.7316/KHNES.2017.28.2.181
  8. Jeong, H., Lee, B. and Lee, K., "Non-Reacting Flow Structure of a Low Swirl Combustion with respect to Inlet Velocities," Journal of the Korean Society of Propulsion Engineers, Vol. 22, No. 6, pp. 56-63, 2018. https://doi.org/10.6108/KSPE.2018.22.6.056
  9. Jeong, H., Lee, B., Han, M. and Lee, K., "A study on the flame liftoff height in a lean-premixed low swirl combustor," J. Korean Soc. Combust., Vol. 23, No. 3, pp. 36-42, 2018. https://doi.org/10.15231/jksc.2018.23.3.036
  10. Oh, J., Kim, M., Heo, P., Lee, J. and Yoon, Y., "GE 7FA+e DLN-2.6 Gas Turbine Combustor : PartII Design of lab Scale Dump Combustor," Journal of the Korean Society of Propulsion Engineers, Vol. 12, No. 5, pp. 51-59, 2008.
  11. Kim, M.K., Lee, J., Park, S., Lee, J.G. and Yoon, Y., "An Experimental Study of Instability Mode Analysis in a Model Gas Turbine Combustor," J. Korean Soc. Combust., Vol. 15, No. 1, pp. 12-21, 2010.
  12. Lee, J.G., Kim, K. and Santavicca, D.A., "Measurement of equivalence ratio fluctuation and its effect on heat release during unstable combustion," Proceedings of the Combustion Institute, Vol. 28, pp. 415-421, 2000. https://doi.org/10.1016/S0082-0784(00)80238-6
  13. Kim, K.T. and Santavicca, D., "Linear stability analysis of acoustically driven pressure oscillations in a lean premixed gas turbine combustor," Journal of Mechanical Science and Technology, Vol. 23, pp. 3436-3447, 2009. https://doi.org/10.1007/s12206-009-0924-0
  14. Kim, K.T., Lee, J.G., Lee, H.J. Quay, B.D. and Santavicca, D.A., "Characterization of forced flame response of swirl-stabilized turbulent lean-premixed flames in a gas turbine combustor," Journal of Engineering for Gas Turbines and Power, Vol. 132, 2010.
  15. Kim, K.T., "Combustion instability feedback mechanisms in a lean-premixed swirl-stabilized combustor," Combustion and Flame, 171, pp. 137-151, 2016. https://doi.org/10.1016/j.combustflame.2016.06.003
  16. Lee, T., Lee, J., Park, J., Han, D. and Kim, K.T., "Staggered swirler arrangement in two self-excited interacting swirl flames," Combustion and Flame, Vol. 198, pp. 363-375, 2018. https://doi.org/10.1016/j.combustflame.2018.10.001
  17. Lee, T., Park, J., Han, D. and Kim, K.T., "The dynamics of multiple interacting swirl-stabilized flames in a lean-premixed gas turbine combustor," Proceedings of the Combustion Institute, 000, pp. 1-9, 2018.
  18. Moon, K., Jegal, H., Gu, J. and Kim, K.T., "Combustion (a)coustic interactions through cross-talk area between adjacent model gas turbine combustors," Combustion and Flame, Vol. 202, pp. 405-416, 2019. https://doi.org/10.1016/j.combustflame.2019.01.027
  19. Kang, D.M., Culick, F.E.C. and Ratner, A., "Combustion dynamics of a low-swirl combustor," Combustion and Flame, Vol. 151, pp. 412-425, 2007. https://doi.org/10.1016/j.combustflame.2007.07.017
  20. Tachibana, S., Yamashita, J., Zimmer, L., Suzuki, K. and Hayashi, A.K., "Dynamic behavior of a freely-propagating turbulent premixed flame under global stretch-rate oscillations," Proceedings of the Combustion Institute, Vol. 32, pp. 1795-1802, 2009. https://doi.org/10.1016/j.proci.2008.06.206
  21. Yilmaz, I., Ratner, A., Ilbas, M. and Huang, Y., "Experimental investigation of thermoacoustic coupling using blended hydrogen-methane fuels in a low swirl burner," International Journal of Hydrogen Energy, Vol. 35, pp. 329-336, 2010. https://doi.org/10.1016/j.ijhydene.2009.10.018
  22. Therkelsen, P.L., Portillo, J.E., Littlejohn, D., Martin, S.M. and Cheng, R.K., "Self-induced unstable behaviors of CH4 and H2/CH4 flames in a model combustor with a low-swirl injector," Combustion and Flame, Vol. 160, pp. 307-321, 2013. https://doi.org/10.1016/j.combustflame.2011.11.008
  23. Therkelsen, P.L., Littlejohn, D. and Cheng, R.K., "Extension of LSI Functionality for Gas Turbine Applications," 23rd ICDERS, 2011.
  24. Gotoda, H., Nikimoto, H., Miyano, T. and Tachibana, S., "Dynamic properties of combustion instability in a lean premixed gas-turbine combustor," Chaos, Vol. 21, 2011.
  25. Thampi, G. and Sujith, R.I., "Intermittent burst oscillations: signature prior to flame blowout in a turbulent swirl-stabilized combustor," Journal of Propulsion and Power, 2015.
  26. Rana, S.C. and Sujith, R., "Bifurcation characteristics and flame dynamics of a ducted non-premixed flame with finite rate chemistry," Combustion Theory and Modelling, 2015.
  27. Karthik, K., Larry, K.B.L and Matthew, P.J., "Forced synchronization of periodic and aperiodic thermoacoustic oscillations: lock-in, bifurcations and open-loop control," J. Fluid Mech., Vol. 838, pp. 690-714, 2018. https://doi.org/10.1017/jfm.2017.879
  28. Lee, J., Park, J., Han, D. and Kim, K.T., "Subcritical Bifurcation of Two Self-Excited Interacting Swirl Flames," J. Korean Soc. Combust., Vol. 24, No. 2, pp. 17-24, 2019. https://doi.org/10.15231/jksc.2019.24.2.017