• 한국결정성장학회지
• /
• 제19권6호
• /
• pp.324-327
• /
• 2009

Mg 합금에서 Ca 첨가가 발화 및 연소 특성에 미치는 영향을 조사하였다. 주조 상태에서 순 Mg은 표면과 내부에 균열과 게재물들이 관찰되었지만 Ca이 첨가된 Mg-Ca 합금에서는 관찰되지 않았다. Mg 합금에 Ca가 첨가됨에 따라 1.5 wt%Ca까지는 발화 온도가 급격히 증가하다가 포화되는 경향을 보였다. 이러한 경향은 Mg-Ca 합금에서 Ca의 고용도와 관련이 있었다. Mg-Ca 합금의 연소 표면에 형성된 MgO 산화층이 발화와 연소를 억제하는 역할을 하였다.

• 한국주조공학회지
• /
• 제26권3호
• /
• pp.146-151
• /
• 2006

In this study, effects of CaD and Ca addtions on microstructure and ignition resistance of pure Mg were investigated. With increasing Ca and CaO contents, the grains in Ca and CaO added Mg were refined and ignition temperatures of CaO and Ca added Mg increased, too. As a result of phase analysis, CaO seemed to be reduced to Ca. $Mg_2Ca$ phase was formed even in 0.1 wt%CaO added pure Mg by reduction mechanism, while $Mg_2Ca$ phase was formed in over 1.35 wt% Ca added pure Mg. Thermodynamical consideration for the reduction mechanism of CaO in pure Mg was carried out.

• 한국토양비료학회지
• /
• 제20권2호
• /
• pp.115-121
• /
• 1987

토양중(土壤中) Ca 및 Mg의 포화비(飽和比)가 상이(相異)하고 가리(加里) 시용량(施用量)이 상이(相異)할 경우 Ca, Mg및 K가 수도수량(水稻收量)에 미치는 영향(影響)을 밝히기 위하여 Ca 및 Mg의 포화비(飽和比)를 81:19, 70:30, 52:48, 45:55 및 31:69로 각각(各各) 조절(調節)한후 가리(加里)를 반당(反當) 9 및 18kg을 시용(施用)하고 진흥(振興)을 공시품종(供試品種)으로 pot 시험(試驗)을 하였는바 그 결과(結果)를 요약(要約)하면 다음과 같다. 1. 토양(土壤)의 Ca 포화비(飽和比) 혹(或)은 Mg 포화비(飽和比)가 높으면 토양용액중(土壤溶液中)의 Ca 농도(濃度) 혹(或)은 Mg의 포화비(飽和比)가 높아 Ca우점토양(優點土壤)에서는 Ca 흡수(吸收)가 많고 Mg 우점토양(優點土壤)에서는 Mg의 흡수(吸收)가 많다. 2. Ca 포화도(飽和度)가 Mg 포화비(飽和比)가 비슷한 경우 토양용액중(土壤溶液中)의 Mg 농도(濃度)가 상대적(相對的)으로 높아 식물체중(植物體中)의 Mg 농도(濃度)가 Ca 농도(濃度)보다 상대적(相對的)으로 높아지는 경향(傾向)이었다. 3. 토양용액중(土壤溶液中) K 농도(濃度)는 Mg 포화비(飽和比)가 높은 토양(土壤)에서는 낮은 경향(頃向)이며 이로 인(因)하여 식물체(植物體) 가리함량(加理含量)도 Mg 포화도(飽和度)가 높은 토양(土壤)에서 적었다. 4. 가리증시(加里增施)는 식물체중(植物體中) K 함량(含量)을 늘리며 Ca+Mg+K에 대(對)한 K의 비(比)를 높이는 결과(結果)로 나타나서 식물체내(植物體內) Ca 혹(或)은 Mg 비(比)를 저하(低下)시켰다. 그러나 그 영향(影響)의 정도(程度)는 Mg가 Ca에 비(比)하여 민감(敏感)하였다. 5. 수도수량(水稻收量) 면(面)에서 볼때 토양중(土壤中) Ca:Mg 포화비(飽和比)는 7:3 정도(程度)가 가장 알맞은 것으로 나타났다. 6. 식물체(植物體)에 의(依)한 K의 흡수(吸收)는 $AK^+/{\sqrt{A(Ca^{{+}{+}}+Mg^{{+}{+}})$에 의(依)해서 영향(影響)은 받으나 $AK^+$ (가리활성도(加里活性度)) 자체(自體)는 Ca:Mg 비(比)에 영향(影響)을 받았다. 즉 $Mg^{{+}{+}}$ 농도(濃度)가 상대적(相對的)으로 높을수록 $AK^+$ 값은 낮아졌다.

• 열처리공학회지
• /
• 제17권3호
• /
• pp.173-179
• /
• 2004

In this study, the influence of heat treatment and Ca contents on the electrochemical behavior was investigated. Mg-Ca alloys, i.e., Mg-0.22wt%Ca, Mg-0.56wt%Ca, Mg-1.31wt%Ca are prepared by ingot metallurgy. As-cast Mg-Ca alloys exhibited better electrochemical properties than pure Mg. Especially, Mg-0.22wt%Ca alloy improves its anode efficiency up to 62% and lowers the OCP up to -1.72VSCE. Microstructure and XRD patterns of Mg-Ca alloys show that additive Ca element is mainly solid-solutioned. While, the others show the microstructure and XRD pattern with large $Mg_2Ca$ at grain boundary. To assess the effect of heat treatment on the as-cast Mg-alloy, the specimens were heat treated at $200^{\circ}C$ for 2 hours under $CO_2$ gas atmosphere. Although corrosion properties of Mg-Ca alloys are somewhat deteriorated by heat treatment at $200^{\circ}C$ Mg-0.22wt%Ca alloy with uniformly distributed nano-sized $Mg_2Ca$ phase in ${\alpha}$-Mg matrix show still better corrosion properties than pure Mg specimen.

• 한국주조공학회지
• /
• 제27권3호
• /
• pp.126-130
• /
• 2007

Oxidation behavior of CaO added Mg and Mg-5Al alloys was investigated. At $500^{\circ}C$, oxidation rate of pure Mg was abruptly increased, while that of CaO added Mg was remarkably reduced with increasing CaO content. As a result of surface analysis by AES, there was the thin oxide layer mixed with MgO and CaO in CaO added Mg. Oxidation behavior of CaO added Mg was similar to that of Ca added Mg. Oxidation rate of 0.6CaO added Mg-5Al alloy was much lower than that of Mg-5Al alloy at $500^{\circ}C$ and both alloys showed the linear weight change at $400^{\circ}C$.

• 동아시아식생활학회지
• /
• 제8권4호
• /
• pp.379-387
• /
• 1998

Magnesium(Mg) plays an important role in lipid metabolism and Mg deficiency but Ca sufficiency Increases serum cholesterol and triglyceride. The relationships of serum Mg, Ca, Ca/Mg ratio with lipids was examined in 79 female college students in Choong-Nam area. Subjects were divided into underweight, normal and overweight groups according to their BMI. The average age, body weight, height and BMI were 21.9yr, 55.9kg, 158.5cm and 22.62kg/$m^2$ respectively. Height was not different between groups. Serum cholesterol and LDL-cholesterol concentrations were significantly lower in the underweight group than other groups. BMI had positive correlations with LDL-cholesterol, atherogenic index (AI) and LDL-cholesterol/HDL-cholesterol ratio(LPH), and negative correlations with HDL-cholesterol/total cholesterol ratio. Serum minerals (serum Mg, Ca, Ca/Mg ratio) and serum lipid concentrations were not significantly different between groups. However, there was a tendency of increasing serum Mg level with increasing serum HDL-cholestrol, HDL-cholesterol/total cholesterol ratio and decreasing serum LDL-cholesterol, LPH, total cholesterol/HDL-cholesterol ratio(TPH) and AI. And there was a tendency of increasing serum Ca level with increasing serum HDL-cholesterol/total cholesterol ratio and decreasing serum triglyceride, LDL-cholesterol, LPH, TPH and AI. And there was a tendency of increasing serum Ca /Mg ratio level with decreasing triglyceride, serum LDL-cholesterol and TPH. This study was limited within serum levels of minerals (serum Mg, Ca and Ca/Mg ratio), serum lipids concerned with CHD, therefore I hope there will be wider efforts to consider about the dietary levels of minerals for presentation of the connection between dietary Mg, Ca and serum lipids.

• 한국주조공학회지
• /
• 제20권6호
• /
• pp.395-399
• /
• 2000

The main interdendritic phase which was formed during early solidification of the ternary Mg-Zn-Ca alloys is the $Ca_2Mg_6Zn_3$ phase. The microstructure of $Mg-6wt%Zn-0.1{\sim}0.3wt%Ca$ alloys consisted of MgZn precipitates and $Ca_2Mg_6Zn_3$ phase formed around the grain boundaries. In the alloys with the highest level of Ca($Mg-6wt%Zn-0.5{\sim}0.7wt%aCa$ alloys), the microstructure revealed wholly $Ca_2Mg_6Zn_3$ phase formed around the grain boundaries. The grain size of Mg-6wt%Zn-Ca alloys decreased significantly with increase in Ca content and, at 0.5wt% Ca or more, grain size becomes constant at about 60 ${\mu}m$. The tensile properties of the as-cast Mg-6wt%Zn-Ca magnesium alloys were improved due to grain refinement by addition of Ca.

• Journal of Nutrition and Health
• /
• 제34권1호
• /
• pp.54-61
• /
• 2001

The Ca and P balance studies were carried out with two different diets varying Ca levels : the current Korean RDA level(normal Ca diet) and the high level (High Ca diet) which was determined by adding 2SD to mean Ca intake of all subjects. The subjects were sever healthy adult woman, aged from 25 to 32 years old. The metabolic studies were conducted for two weeks with a days recess in between : during the fist week with normal Ca diet and during the second week with high Ca diet. The composition of nutrients excepting Ca of both diets was similar to subjects usual intake. The result were summarized as follows: Mean daily Ca intake was 728.8mg from norma Ca diet and 945.5mg from high Ca diet. Fecal excretion of Ca increased significantly(p<0.05) on high Ca diet, but urinary excretion of Ca did not show any differences between the two diet periods. There were also no significant differences in Ca retention between the two diet periods but it tended to be greater during high Ca diet period: 112.1mg/day during normal Ca diet period vs 208.2mg/day during high Ca diet period. Mean apparent Ca absorption was 41.2% on normal Ca diet and 42.1% on high Ca diet, indicating it was not affected by high Ca intake level used in this study. On the contrary, P retention was significantly increased up to 109.4mg/day with high Ca diet as compared to- 41mg/day with normal Ca diet. There were no significant differences in fecal and urinary excretion of P but those to be lower during high Ca diet period. The above results showed that higher Ca intake more than current RDA(700mg/day), in the level of 945.5mg/day, could increase Ca retention through Ca absorption comparable to the rate appeared on RDA level intake. P retention was also improved by high Ca intake. Therefore, higher Ca intake than the current RDA level seemed to produce favorable effects on bone health in adult women. However, the current RDA level seemed to be relatively appropriate, considering the results that all the subjects but one maintained positive Ca balance with normal Ca diet. (Korean J Nutrition 34(1):54-61, 2001)

• 한국주조공학회지
• /
• 제38권4호
• /
• pp.75-81
• /
• 2018

This study examined the effect of the CaMgSn ternary phase on the aging response of the Mg-Sn-Zn alloy. The results revealed that the CaMgSn ternary phase formed in rod-like or needle-like shapes in Mg-3Zn-0.3Ca-xSn (x=1.5, 3, and 5 wt%) alloys and its size decreased as the Sn content increased from 1.5 wt% to 5 wt%. The Mg-3Zn-0.3Ca-5Sn alloy with a relatively fine CaMgSn phase was subjected to solution heat treatment and an aging process. Both the Mg-5Sn-3Zn-0.3Ca and Mg-5Sn-3Zn (base alloy) alloys had similar peak hardness values throughout all aging temperatures but the time-to-peak hardness in the Mg-5Sn-3Zn-0.3Ca alloy was 24-36 hours-earlier than that in the base alloy. Precipitates in the Mg-5Sn-3Zn-0.3Ca alloy were more refined than those in the Mg-5Sn-3Zn alloy and were mostly formed on basal planes. The $Mg_2Sn$ phase formed in either plate-like or rod-like shapes in the Mg-5Sn-3Zn alloy, whereas block-shaped $Mg_2Sn$ particles also formed in the Mg-5Sn-3Zn-0.3Ca alloy.

• Korean Chemical Engineering Research
• /
• 제57권6호
• /
• pp.812-825
• /
• 2019

국내에서 채광되는 백운석(dolomite, $CaMg(CO_3)_2$)을 회분식 형태의 마이크로웨이브 소성로($950^{\circ}C/60min$)에 의해 소성하여 경소백운석($CaO{\cdot}MgO$)을 제조하였다. 국내에서 산출된 두 개의 백운석 시료를 대상으로 경소백운석($CaO{\cdot}MgO$) 제조 후 수화 특성을 규명한 결과 반응성이 다름을 규명하였다. 경소백운석($CaO{\cdot}MgO$)의 수화 특성의 반응성을 이용하여 강산성 양이온 교환수지와 반응 시켜서 MgO를 분리하는 조건을 실시하였다. 분리 실험 조건은 경소백운석($CaO{\cdot}MgO$)과 $R-SO_3H$ (1:12 mass %)로 칼슘이온 흡착($Ca-(R-SO_3)_2$)하여 MgO를 분리하였다. 분리 후 MgO의 함량은 94 mass % 이상으로 분리되었다. 분리된 MgO를 $950^{\circ}C$, 60 min 동안 열처리 후 MgO의 순도는 96 mass %로 나타났다. 그리고칼슘 이온이 흡착된강산성 양이온교환수지($Ca-(R-SO_3)_2$)와 NaOH, $CO_2$ gas 반응에 의해서 98 mass %의 $CaCO_3$를 합성하였다.